Independent Laboratory Tests Kaivac's OmniFlex Cleaning System ATP Reduction Exceeds 99 Percent


Hamilton, OH -- The TURI Surface Solutions Laboratory at the University of Massachusetts, in Lowell, has reported the results from a series of tests that compared the cleaning effectiveness of Kaivac's new AutoVac Cleaning System with more conventional floor cleaning methods, such as using a microfiber mop and an autoscrubber.

The AutoVac, which is part of Kaivac's OmniFlex(TM) Crossover Cleaning System, was recently certified by the National Floor Safety Institute (NFSI). It is also entered in the "equipment" category of this year's ISSA Innovation Awards Program.

To perform the tests, TURI researchers first cleaned and then sterilized an eight-by-four-foot area of a finished vinyl composite tile (VCT) floor. Next, they used an ATP meter to verify that the floor was hygienically clean.

Then, the following test steps were taken:

· Researchers applied freshly squeezed seedless grape juice diluted with water to the floor and allowed it to dry before conducting baseline ATP readings.

· They cleaned one area of the floor with a microfiber mop and Kaivac's KaiO(TM) multipurpose floor cleaning solution, diluted per manufacturer's instructions.

· They cleaned another section of the floor using the same cleaning solution using an automatic scrubber.

· Finally, using the same cleaning solution, they made three passes with an OmniFlex AutoVac to clean a third section of the floor.

In each case, once the floor was dry, researchers collected ATP readings.

The results indicated that all three cleaning methods lowered ATP levels. However, the report indicated that the average reduction in ATP using the OmniFlex system matched-or exceeded-the effectiveness of an automatic scrubber.

Actual reduction in ATP with the AutoVac Cleaning System was almost 100 percent. (See Sidebar: High Points of the TURI Report)

"Our own testing indicated the [cleaning] effectiveness of the system would be very high," says John Richter, Technical Director for Kaivac. "However, these results were very impressive, even exceeding what we anticipated."

Sidebar: High Points of the TURI Report

· The overall results of the studies indicate the Kaivac AutoVac system performed "as well as or better than the automatic scrubber" as measured by the reduction in the amount of ATP and bacteria on the floor after cleaning.

· The mop was found "to be an ineffective way of removing bacteria from a hard surface."

· Both the AutoVac system and the automatic scrubber "had significant reduction in ATP levels" of plus or minus 99 percent of the test floor area.

· The vacuum removal of bacteria using the AutoVac system "is instrumental in eliminating the bacteria from the floor and minimizing cross contamination."

Visit Kaivac on Facebook at: http://tiny.cc/sbkd5.

About Kaivac, Inc.

Headquartered in Hamilton, Ohio, Kaivac, Inc. delivers complete science-based cleaning systems designed to produce healthy results and outcomes while raising the value of cleaning operations and the professionalism of the worker. The originator of No-Touch Cleaning® and the OmniFlex(TM) Crossover Cleaning System, Kaivac offers an integrated portfolio of environmentally friendly cleaning products designed to remove the maximum amount of soil and potentially harmful biopollutants in the most cost-effective manner possible. For more information, visit www.kaivac.com.

Company contact information:

Tom Morrison, vice president of marketing

Kaivac, Inc.

401 South Third Street

Hamilton, OH 45011

Phone: 513-868-4227

Email: info@kaivac.com

Contact: Robert Kravitz

Phone: 773-525-3021

E-mail: rkravitz@rcn.com

Contact This Company

Related

All Topics