Waste Handling Equipment

Waste Handling Equipment, Fluid & Gas Flow Equipment

Submicron Water Filters are offered with 5 micron sediment wrap.

November 24, 2015

Available with 5-micron sediment wrap to reduce dirt, sand, sediment, rust, and fine particles, ULTRA-D Eco uses electroadsorptive technology for water filtration. This configuration is available with all ULTRA-D filter models: original media, original with carbon, original with NSF-approved microbial agent (Agion silver), and original with Agion silver and carbon. Beneficial for point-of-entry as well as point-of-use applications, filters come in 2.5 and 4.5 in. ODs and 10–40 in. lengths.
Read More

Material Handling & Storage, Health, Medical and Dental Supplies & Equipment, Waste Handling Equipment

Two-Sided Carts increase picking/stocking efficacy.

November 16, 2015

Capable of supporting up to 1,000 lb, 52 x 29 x 62 in. Dual-Sided Picking/Stocking Carts are pre-assembled with 5 in. mold-on rubber casters. Cart is also equipped with 8 in. tall ShelfMax8™ bins, which come in 15 5/8 x 11 1/8 x 8 in. (30806) and 15 5/8 x 22 ½ x 8 in. (30826) sizes and 4 colors: red, blue, yellow, and clear. While 4 angled shelves optimize picking and stocking operations, flat bottom shelf provides additional storage options. Read More

Chemical Processing & Waste Management, Test & Measuring Instruments, Waste Handling Equipment

Phosphorous Analyzer monitors water treatment processes.

November 2, 2015

Configurable with 1 or 2 channels, Liquiline System CA80PH is designed for measurement of orthophosphate, making it suited for all critical measurement and control points of water/wastewater treatment. Colorimetric analyzer is available in 4 measuring ranges: 2 use standard molybdenum for low range measurement down to 50 µg/L and 2 use molybdate vanadate method for high range measurements up to 50 mg/L. Typical sample analysis takes 8–11 minutes, depending on method used. Read More

Electrical Equipment & Systems, Waste Handling Equipment, HVAC, Green & Clean

A/C Coil Ultraviolet System features quick-release lamp.

October 27, 2015

Equipped with quick-release lamp that allows for replacement without tools, BLU QR™ utilizes standard germicidal wavelength lamp for safe disinfection and protection of AC coil surfaces from bacteria, viruses, mold growth, and odors. System comes with 4 mounting options, including magnetic mount and multiple through plate mounting styles. System's 24 Vac ballast is designed to be mounted either in air handler control panel itself or external to HVAC air handler unit. Read More

Waste Handling Equipment, Green & Clean

Recycling System processes aerosol cans.

October 26, 2015

Utilizing rack and paw gear, Aerosolv 360® reduces effort needed to process aerosol cans. Fully enclosed, dual seal system seals inside at point of puncture and outside when can is being processed. Alignment cone and 2-way vent pin direct flow straight into drum, minimizing maintenance. Featuring replaceable filter components, carbon filter captures odors and potentially harmful VOCs. Additional features include built-in counter, integrated lockout system, and insulated non-stick coating. Read More

Material Handling & Storage, Waste Handling Equipment, Packaging Equipment

Bin Lids feature 2-piece hinged design.

October 21, 2015

Available for 30280, 30281, 30282, 30283, 30286, and 30290 Super-Size AkroBin® models, Clear Plastic Lids cover and protect bin contents while creating access door even when bins are stacked. Made of clarified polypropylene, lids have integrated stop tabs that prevent stacked bins from shifting. They can be used with optional length/width dividers, mobile kit, window inserts, adhesive labels, and card stock holders to create storage system for large and bulky items. Read More

Waste Handling Equipment

Cone Crusher processes up to 805 tons per hour.

October 19, 2015

Available from 200–500 hp, Patriot™ Cone Crusher uses bronze sleeve bearings for all moving components that are load bearing or perform load transmission. Fail-safe hydraulics defend against damaging mechanical overload, while standard relief valves within dual acting tramp release cylinders provide immediate, alternative protection should accumulator fail. In event of force overload, alarm can activate or optional advanced sensing technology will automatically take necessary corrective action. Read More

Material Handling & Storage, Health, Medical and Dental Supplies & Equipment, Waste Handling Equipment

Dividable Grid Containers provide applicational versatility.

September 25, 2015

Akro-Grid models 33103 (10 7/8 x 8 ¼ x 3 ½ in.), 33162 (16 ½ x 10 7/8 x 2 ½ in.), 33165 (16 ½ x 10 7/8 x 5 in.), and 33222 (22 ½ x 17 ½ x 12 in.) are work-in-process containers compatible with racks, shelving, and automated material handling equipment. Molded-in grid system with divider slots allows creation of compartments down to 1 1/8 in.², and stacking rims and external ribbing lend to strength. Injected-molded from industrial polymers, containers are resistant to solvents and chemicals. Read More

Waste Handling Equipment, HVAC, Fluid & Gas Flow Equipment

Pollution Control Unit meets UL-1978 standard.

September 18, 2015

Using 3-stage mechanical filter arrangement, Grease-Trapper PCU removes grease, smoke, and odors from kitchen exhaust air. Activated carbon panels remove odor molecules prior to discharging air, reducing impact of exhaust to surrounding areas. Built in accordance with NFPA 96, Grease Trapper offers capacities up to 12,000 cfm and uses MERV filters to ensure minimum overall particulate removal efficiency of 95%. Independent pressure switches signal when any filter stage needs replacing. Read More

Waste Handling Equipment, Chemical Processing & Waste Management, Green & Clean

Membrane Process addresses ZLD and high recovery plant needs.

September 4, 2015

Intended for facilities requiring Zero Liquid Discharge (ZLD) or very high recovery, AquaR2RO™ features membranes configured to handle difficult-to-treat waters. Design tolerates feed characteristics high in organics, dissolved oil, and turbidity. In addition to maximizing recovery, process minimizes volume of concentrate to treated in thermal-based ZLD with brine concentrator and/or crystallizer. In some applications, this membrane process achieves >98% recovery. Read More

Chemical Processing & Waste Management, Waste Handling Equipment, Green & Clean

Seawater Reverse Osmosis System solves biofouling issue.

September 3, 2015

Consuming up to 20% less energy than conventional SWRO, LoWatt™ Desalination Technology integrates UF membrane pretreatment and nutrient removal step while continuously deactivating bacteria without using any chemicals to mitigate biofouling. System also uses chemical-free, online cleaning and flushing process that minimizes cleaning cycles and increases plant availability. Read More

Waste Handling Equipment, Plant Furnishings & Accessories, Materials & Material Processing

Leak Diverter Kits contain roofs and pipe leaks.

September 3, 2015

Applicable regardless of leak type, PIG® Leak Diverter Combination Kit for Roofs & Pipes provides all products needed for response and control: pipe and roof leak diverters, drainage hoses, hanging straps, absorbent mats/wipes, pipe wrap, and multipurpose repair putty. All items, supplied in adjustable carrying bag, minimize potential for damage to other products and processes as well as prevent slippery floors. Leak diverters are constructed of vinyl-coated, impermeable tarp material. Read More

Waste Handling Equipment, Material Handling & Storage, Chemical Processing & Waste Management, Green & Clean

Material Recovery Station separates liquids from solids.

July 27, 2015

With screening panel set inside leak-proof, bulk plastic container, Model MRS-30 automatically screens out and captures solid particles while allowing liquids to safely pass through and accumulate in container bottom. When filled to its 30-gal capacity, self-contained unit may be drained to allow liquids to be reprocessed and reused on-site while solids may be sold as highly marketable scrap. Recycling system is forkliftable without pallet and stands on 44 x 44 in. footprint. Read More

Waste Handling Equipment, Chemical Processing & Waste Management

Self-Contained Compactors suit limited space applications.

July 15, 2015

Designed as integral compactor, power unit, and container, SCM Series provides safe and sanitary handling of general waste. Single-cylinder commercial units come in 10 frame sizes with capacities from 7–23 yd³. When full, entire unit is loaded on roll-off hoist truck for transport to disposal site. Units come standard with 5 ft wide rectangular container for space savings, but 6, 7, and 8 ft models are also available. All offer 28 x 46.5 in. clear top opening and max packing force of 26,400 lb. Read More

Waste Handling Equipment

Crusher provides low-friction cutting action.

July 10, 2015

Available with variety of auxiliary equipment, DELUMPER 1075 LP Crusher reduces hard or soft, heat sensitive, sticky or wet agglomerates and lumps at high volume without degrading material or causing rise in temperature. Unit features fully enclosed stainless steel stand and hinged hopper that tilts to allow access to interior components for cleaning and service. Extended cutting teeth rotate completely through heavy bar cage, self-clearing slots with each rotation. Read More

Waste Handling Equipment

Portable Containment Pool offers 20-gallon capacity.

June 25, 2015

Ready to use in 3 seconds, 20-gallon Tank Trap™ offers single-use option for emergency spills and leaks from vehicles with low ground clearance. Users can drive over 4 in. high sidewalls and sides will immediate pop back up. Featuring stored size of 16 x 18 x 7 in., portable pool is vacuum-packed to save space with easy tear-open foil packaging and carry handle. Typical applications include lift trucks, accidents, and equipment leaks. Read More

Waste Handling Equipment, Green & Clean

Wastewater Treatment System targets oil and gas industry.

June 9, 2015

Used in oil recovery projects, Once-Through Flash™ technology recycles thermal heat produced by Once-through Steam Generators. Recycled heat is then used to convert produced water into clean water with high purity. OTF yields water recycle rates of more than 95%, thus achieving compliance with Alberta Energy Regulator’s Directive 081 that sets water disposal limits and includes detailed reporting requirements for thermal in situ oil sands operations. Read More

Waste Handling Equipment, Chemical Processing & Waste Management

Nonferrous Separator produces premium, high-grade zorba.

June 4, 2015

Combining 3 eddy current separators, Rougher/Cleaner/Scavenger System is positioned downstream of ferrous separation and trommel screen to size material. Rougher aggressively maximizes recovery of nonferrous metals, while Scavenger recovers any zorba misplaced by Rougher. Cleaner then removes unwanted material from final zorba product. Downstream of RCS system, sensor sorting equipment may be used to separate stainless and lead. Read More

Chemical Processing & Waste Management, Waste Handling Equipment, Green & Clean

Wastewater Filtration System helps save water in car washes.

June 3, 2015

To save water during car wash operations, Hydrokleen Wastewater Filtration System takes 100% of all collected wash water, filters it, eliminates odors, and recirculates water back into existing washing system. Whether system is manual wash wand or automated wash bay, only fresh water required is for final rinse to remove recycled water used for washing from vehicle. System is completely above ground so no additional construction is necessary. Read More

Material Handling & Storage, Waste Handling Equipment

Septage Receiving System offers automated rock removal.

April 27, 2015

With SPIRALIFT® SR Septage Receiving System, TASKMASTER TT grinder uses trap system to settle out rocks with high level of efficiency. Automated rock removal option has automated gate valve that opens on pre-planned cycle and lets rocks fall into enclosed screw conveyor. They are then conveyed directly into bin for disposal without operator assistance. System is preferred by plants that do not want to remove rocks manually. Read More