HVAC

HVAC

Dry Dust Filter is suitable for biofuels plants.

October 19, 2009

Designed to filter fine powders and dusts, Big Round Filter features self-contained cleaning system that doesn't require compressed air. Unit's rotating arm, 2 sealed bearings, and direct-drive gear box simplify maintenance. Inlet options include tangential inlet, for heavy loading applications in receiving and grinding areas, and high-entry inlet suited for loading applications such as distillers, dried grains, and load-out areas. Read More

HVAC

Bladeless Fan expels 119 gal of air/sec.

October 19, 2009

Dyson Air Multiplier(TM) fan features loop amplifier, 1.3 mm annular aperture, and airfoil-shaped ramp that amplify air motion by 15x. It also includes energy-efficient brushless motor at machine base. Available in two 10 in. models and 12 in. model, device allows air speed to be adjusted with dimmer switch. Read More

Test & Measuring Instruments, HVAC

Non-contact Pyrometer suits metal processing applications.

October 16, 2009

Dependent on emissivity ratio but not on absolute emissivity, thermoMETER CT ratio provides measuring range of 700-1,800°C at maximum ambient temperature of 250°C. It enables connection to Profibus, Ethernet, USB, RS232, or RS485, and can be used as standard single-channel IR sensor or as ratio pyrometer. Operating with optical fiber between sensor and electronics, unit is unaffected by electromagnetic radiation. Read More

Material Handling & Storage, HVAC

Compressor is available from 500-650 hp.

October 16, 2009

Featuring 2 independently operating compressors, HSD compressor delivers flows from 1,632-3,002 cfm and pressures from 100-217 psig. Each HSD incorporates 2 individual compressor units including motor, Sigma Profile airend, separator aftercooler, draintrap and filtration. Sigma Controls, connected via Profibus, allow for full automatic monitoring of critical operating and maintenance indicators. Read More

Test & Measuring Instruments, HVAC, Electronic Components & Devices

Temperature Sensor includes I2C interface.

October 14, 2009

Available in 8-pin MSOP and 2 x 3 mm DFN packages, Model MCP9804 provides accuracy of +0.25°C typical and ±1°C from -40 to +125°C, as well as static current consumption of 200 µA. Silicon-based unit features programmable shutdown to extend battery life, alert feature for over- and under-temperature window monitoring, and critical temperature-alert feature for over-temperature protection. Applications include industrial freezers, consumer electronic devices, and engine temperature monitoring. Read More

HVAC, Welding Equipment & Supplies

Portable Dust and Fume Collector offers 3-stage filtration.

October 12, 2009

Zephyr® III features metal filter that functions as spark trap, main filter for fine particle removal, and carbon filter for odors and gases. Either Gold Cone® HemiPleat® standard- or high-efficiency or DuraPleat® washable filters can be used. System includes manually activated Venturi-assisted pulse cleaning system and quick-clamp for simplified cartridge sealing and removal. Operated via 110 v/1 ph 60 Hz power cord, it offers airflow capacity of 700 cfm at capture hood. Read More

HVAC

Round Dampers feature A-60 fire rating.

October 9, 2009

Made of stainless steel, 700-A60R Series ranges from 12-36 in. in diameter and is available with electric or pneumatic actuation. Fully automatic units meet all requirements in accordance with IMO FTP Code, Annex 1, Part 3. Under terms of US-EC Mutual Recognition Agreements on Marine Equipment, 700-A60R line has also earned European Wheelmark of conformity. Read More

Test & Measuring Instruments, HVAC, Sensors, Monitors & Transducers

IR Temperature Sensor has measuring range from -30 to 1,600°C.

October 9, 2009

Two-wire, 4-20 mA loop-powered, programmable thermoMETER CSmicro 2W has built-in processing electronics to linearise sensor output. It features silicon coated optics (15:1 or 75:1) and offers system accuracy of ±1.0% and ±0.3% of reading, respectively. Optional USB connection and CompactConnect software enable user to setup and configure sensor or to change emissivity to suit target material. Sensor can be used in ambient temperatures up to 130°C without having to cool sensor head. Read More

HVAC

Ducted Air Purifier incorporates photo-catalytic oxidation.

October 8, 2009

Capable of providing up to 3,000 sq ft of complete air purification, CX3000GS ducted air purifier removes particles, neutralizes chemicals, and abates living organisms. Photo-catalytic oxidation uses UVC light to activate highly reactive catalyst, and this converts toxic compounds into benign constituents such as water and carbon dioxide. Electronic service lights indicate when filters and UVC lamps require replacement. Read More

HVAC, Thermal & Heating Equipment

Water Pump Heater is customizable.

October 7, 2009

Available from 4-24 in. configurations, Freeze Sentry(TM) water pump heater thaws ice and protects volutes from harsh winter freezing. Portable unit with 12 or 120 V plugs can control equipment temperatures with fast, consistent heat. It can be used to securely cover and heat pump volutes, priming systems, and inlet/outlet areas while at same time maintain open-access to critical valves. Read More

HVAC, Controls & Controllers, Sensors, Monitors & Transducers

Viscosity/Temperature Control System is unaffected by vibration.

October 6, 2009

Maintenance-free, ViscSense® viscosity control system is unaffected by flow and vibration and can measure low shear viscosities from 0-600 cps and temperatures to 220°F, depending upon material. Compatible with any PLC, it operates on 24 Vdc and provides 4-20 mA, RS232, and CANBUS outputs. Weighing 8 oz, unit features ½ NPT pipe connection, touch screen controller, and acoustic wave sensor that can be installed in-line to continuously monitor viscosity and temperature. Read More

HVAC, Controls & Controllers

Fan Controller regulates RPM according to real-time demand.

October 5, 2009

To ensure required linear air velocity is maintained despite external influences, C-600 controls and modulates fan RPM based on real-time air velocity and/or temperature measurements. User-programmable air velocity and temperature set points are leveraged to increase or decrease fan RPM, and I²C- or UART-based communication to host system can relay real-time information. If cooling fan is unable to generate desired flow requirement, controller initiates low-flow alarm to system. Read More

Adhesives & Sealants, HVAC, Materials & Material Processing

Curb Tape seals roof-mounted A/C units from water/dust.

September 30, 2009

Contractor-grade Curb Tape seals roof curbs to HVAC units, preventing rain, moisture, and dust from damaging sensitive electronics. Flexible tape conforms to irregular roof surfaces and features single-side of rubber-based pressure-sensitive adhesive. It is manufactured from blend of closed cell neoprene, EPDM, and SBR in choice of soft, medium, or hard densities. Available in various thicknesses and widths, product passes FM VSS No. 302 for flammability. Read More

Test & Measuring Instruments, HVAC, Controls & Controllers

Environmental Protection Controller fits in 19 in. racks.

September 30, 2009

Requiring 2U rack space, Model EPC-2374R serves as primary device for temperature, humidity, and moisture protection. System operates as controller, data logger, meter, event recorder, and early warning system with power fail output and RTD inputs. It is suited for industries such as information technology, automation, broadcasting, telecommunications, and audio control. Read More

Transportation Industry Products, HVAC, Controls & Controllers, Fasteners & Hardware

Slip Joints/Weld-On Hinges suit removable door applications.

September 29, 2009

Allowing instant access to cabinet interior, Slip Joints comes in various sizes from 1 ½ to 3 in. long and 1 7/16 to 3 in. open width, with either blank leaves or standard hole patterns. Offering alternative to continuous, butt, or slip hinges, Weld-On Hinges have no leaves or fasteners to remove. They come in 12 sizes with options for fixed pin, fixed pin with grease fitting, or removable pin. All removable hinges are available in stainless, steel, and aluminum. Read More

HVAC

Compact Mist Collector operates at 600 cfm.

September 25, 2009

Featuring 24 x 23.5 in. footprint, MistMax(TM) MM600 has filter technology that provides efficiency and long-life performance up to 5 yr. Heavy-duty components include heavy-gauge steel in cabinet and floor stand, and MM600 operates at 600 cfm with sound level of only 70.0 dp(A) at 5 ft. Options include IntelliTouch(TM) energy saving control panel. Product is suited for capturing mist in small areas and in multiple station applications. Read More

HVAC, Green & Clean

Air Conditioning Units have 95-98% sensible heat ratio.

September 25, 2009

Using eco-friendly R-410A or R-407c refrigerant, EN Series offers models from 7.5-30 refrigeration tons available as factory-assembled units or as ready-to-assemble on-site kits to fit through 80 x 36 in. doorways. Units have free-cooling and dual-cooling capabilities, and double-wall case construction separates R-value insulation from air stream to enhance IAQ. Airflow and compressor flexibilities can pinpoint any intake temperature set point required with minimal energy cost increases. Read More

HVAC, Chemical Processing & Waste Management, Fluid & Gas Flow Equipment

High-Efficiency Air Filter is resistant to corrosion.

September 23, 2009

MEGAcel(TM) I filter with Helior(TM) ePTFE media is constructed with tapered aluminum separators to optimize pleat pack resistance. Its Helior HEPA/ULPA media is manufactured and tested in ISO Class 7 environment, eliminating any potential for contamination, and resists corrosion. Also, energy consumption is minimized due to low operating resistance. Filter is suited for healthcare, pharmaceutical, electronic, food processing, and laboratory environments. Read More

HVAC, Green & Clean

Vertical Gas Fired Air Handler has energy efficient design.

September 15, 2009

Available with staged heating from 75-400 MBH to provide right amount of heat depending on outside temperature, Model CAUA helps save on energy usage. Unit can handle up to 100% outside air and has multiple options for air mixing boxes, filter boxes, and discharge arrangements. With optional separated combustion and outside supply air capability, unit suits buildings requiring indoor air quality control. It can be coupled with M Series condensing unit to provide staged cooling as well. Read More

HVAC

Air Handling Units offer unlimited range of configurations.

September 15, 2009

Featuring bolted construction with lifetime ultra-low leakage seal, custom CTM-TB Series has baked electrostatic powder coat finish on exterior, polyurethane foam injected insulation up to R-26, and dual-gasketed access doors with roller-cam latch mechanisms. Units may be designed with integral desiccant wheels, runaround heat recovery coils, heat pipe coils, and air-to-air heat exchangers. Typical applications include pharmaceutical, research laboratories, and healthcare facilities. Read More